Coolant Green RXSOL G 93-94

Chemical Name

Concentration

CAS Number

EC Number

R Phrases*

Symbo

Ethlene Glycol

30-35%

107-21-1

203-473-3       

R-22

 603-027-00-1

Contact with skin

Remove contaminated clothing immediately and drench affected skin with plenty of water. Then wash with soap and water

Contact with eyes

If substance has got into eyes, immediately wash out with plenty of water for at least 15 minutes.Seek medical advice 

Ingestion

Never give anything by mouth to an unconscious person. Give plenty of water to drink. Seek medical advice if necessary

Inhalation

Vapours or aerosols may cause irritation of eyes, nose and respiratory tract. Remove patient to fresh air

General

In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible) (S45)

Personal Precautions

Wear protective clothing as per section 8.

Environmental Precautions

No special precautions are required for this product.

Immediate Actions

Shut off source of leak if safe to do so.

Clean Up Actions

Absorb spillage in suitable inert material.Flush spill area with copious amounts of water.

Special Precautions

Wear protective clothing as per section 8.

Handling

The usual precautions for handling chemicals should be observed. Eyewash bottles should be available

Storage

Keep only in the original container in a cool, well ventilated place (S3/9/49). Protect from frost

 Exposure Limits

TWA value 52 mg/m3 ; 20 ppm (OEL (EU))
STEL value 104 mg/m3 ; 40 ppm (OEL (EU))
Skin Designation (OEL (EU))
The substance can be absorbed through the skin.
TWA value 10 mg/m3 (EH40 (UK))
TWA value 52 mg/m3 ; 20 ppm (EH40 (UK))
STEL value 104 mg/m3 ; 40 ppm (EH40 (UK))
Skin Designation (EH40 (UK))
The substance can be absorbed through the skin.
Skin Designation (EH40 (UK))
The substance can be absorbed through the skin.

 Exposure controls

Personal protective equipment:

Respiratory protection: Suitable respiratory protection for higher concentrations or
long-term effect: Gas filter EN141 Type A for gases/vapours of organic compounds
(boiling point >65 °C).

Hand protection:


Chemical resistant protective gloves (EN 374) Suitable materials short-term contact and/or splashes (recommended: At least protective index 2, corresponding > 30 minutes of permeation time according to EN 374) butyl rubber (butyl) - 0.7 mm coating thickness.
Supplementary note: The specifications are based on own tests, literature data and information of glove manufacturers or are derived from similar substances by analogy. Due to many conditions (e.g. temperature) it must be considered, that the practical usage of a chemical-protective glove in practice may be much shorter than
the permeation time determined in accordance with EN 374. Manufacturer's directions for use should be observed because of great diversity of
types.



Eye protection:

Safety glasses with side-shields (frame goggles) (EN 166)

Body protection:

Body protection must be chosen depending on activity and possible exposure, e.g. apron, protecting boots, chemical-protection suit (according to DIN-EN 465).

General safety and hygiene measures:
Handle in accordance with good industrial hygiene and safety practice. Wearing of
closed work clothing is required additionally to the stated personal protection equipment.

Occupational exposure controls

No respiratory protection is required unless subject to contact with substance mist. Wear suitable protective clothing, including eye/face protection and gloves (plastic or rubber are recommended

Odour

Specific

Appearance

Green Color, Liquid,  soluble in water

pH

9.50  at 100 % concentration

Boiling point

NA

Vapour  density

N.A

Melting point

36iC

Completely soluble in water

Specific gravity (water=1)

1.092 - 1.095

Non combustible

Acute  effects

ingestion  of  this  product  is harmful.  Even   small  amounts  of  product  may cause  serious  health problems  (stomach  pain,  nausea,  sickness,  diarrhoea,  etc.).  This  product  may  slightly  irritate  mucosas,  the  upper. respiratory  tract,  eyes,  and  skin.  Exposure  symptoms  may include:  sting,  cough,  asthma,  laryngitis,  respiratory. disorders,  headache,  nausea  and  sickness

Ethylene  glycol

following  ingestion  it initially  stimulates  the  CNS;  later  on  depression  results.  Renal  damage  with anuria  and  uremia  may occur.   Symptoms  of  over  exposure  are:  vomiting,  somnolence,  difficulty  in   breathing,convulsions. The lethal dose in man is approximately 1.4 l/kg. The route of entry is inhalation and ingestion.

Full text of hazard symbols and R-phrases if mentioned as hazardous components in chapter 2: Xn Harmful. 22 Harmful if swallowed. 63 Possible risk of harm to the unborn child. Vertical lines in the left hand margin indicate an amendment from the previous version. If you have any queries relating to this MSDS, it's contents or any other product safety related questions, please write to the following e-mail address:rxsolchemicals@gmail.com/ .

The data contained in this safety data sheet are based on our current knowledge and experience and describe the product only with regard to safety requirements. The data do not describe the product's properties (product specification). Neither should any agreed property nor the suitability of the product for any specific purpose be deduced from the data contained in the safety data sheet. It is the responsibility of the recipient of the product to ensure any proprietary rights and existing laws and legislation are observed.
 

DISCLAIMER OF LIABILITY :The information in this SDS was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use or disposal of the product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or disposal of the product. This MSDS was prepared and is to be used only for this product. If the product is used as a component in another product, this MSDS information may not be applicable.